2001 4Runner build/fix log

[Silverback]

I used to use those many moons ago working on F15 avionics. Nice tool!

 

[taco4x4rar]

Issues list to knock out before Oct trip in no particular order:

1 - Front axle swap to 4.30 gears
2- Resolve power steering fluid leak
3- Install auto transmission shift kit/ new solenoids
4- Build cargo storage/ drawer
5- Fridge slide out
6- Battery box
Still debating #7 - Dual battery setup w/ 25 series
8- Wind fairing for RTT

This week I will finish up the e locker wiring and installing the actuator armor.

Where did you find the 4.30 gears, I'd really like some for my tundra

 

[unevolved]

Nice tool!

Thanks, I get that a lot.

 

[Silverback]

 

[tx_shooter]

I bought the axl

Where did you find the 4.30 gears, I'd really like some for my tundra

Came with the e locker rear axle and matching front.

 

[tx_shooter]

Weekend work done. So the front axle was finally swapped out to 4.30 gears so now the front and back match. I did finally get around to knocking out an oil change today. Next up appears to be replacing the shocks. The front shock bushings are shot to hell and the backs are not much better. So next weekend will see the Transgo shift kit and new shift solenoids installed. Then shocks and outer tie rods some time after that but hopefully sooner than later. At least the list is growing shorter.

From before
Issues list to knock out before Oct trip in no particular order:

1 - Front axle swap to 4.30 gears
2- Resolve power steering fluid leak
3- Install auto transmission shift kit/ new solenoids
4- Build cargo storage/ drawer
5- Fridge slide out
6- Battery box
7 - Dual battery setup w/ 25 series
8- Wind fairing for RTT
9- New rotors and pads
10 - Shocks
11 - Outer tie rods
12- E-locker actuator rebuild


The list is growing faster than it is shrinking....

 

[tx_shooter]

Did a simple fab up for a restraining plate to go under the battery. This plate with the factory battery hold down will keep the battery firmly in place for now. Also installed an iBolt tablet mount for navigation/ camera use later.





Updated to do list:

2- Resolve power steering fluid leak
3- Install auto transmission shift kit/ new solenoids
4- Build cargo storage/ drawer
5- Fridge slide out
7 - Dual battery setup w/ 25 series
8- Wind fairing for RTT
10 - Shocks
11 - Outer tie rods
12- E-locker actuator rebuild
13- Camp Box build

Done:
1 - Front axle swap to 4.30 gears
9 - New rotors and pads
6 - Battery box
14 - tablet holder mount

 

[tx_shooter]

Installed the Transgo shift kit on the truck setting today. Also replaced the shift solenoids too. So far it is a much needed improvement to get rid of the "soccer mom" shifts. I have a small leak to resolve but it should be knocked out pretty quick.

Also picked up a tablet and am testing it out for BCN use. The tablet mount works great.

Mileage: 265,000 roughly

So the list stands today at:

2- Resolve power steering fluid leak
4- Build cargo storage/ drawer
5- Fridge slide out
7 - Dual battery setup w/ 25 series
8- Wind fairing for RTT
10 - Shocks
11 - Outer tie rods
12- E-locker actuator rebuild
13- Camp Box build

Done:
1 - Front axle swap to 4.30 gears
9 - New rotors and pads
6 - Battery box
14 - tablet holder mount
3- Install auto transmission shift kit/ new solenoids

 

[tex]

So when is this heap getting sold? I thought you had a buyer or 2 a few weeks back. Sounds like its a lot of work.

 

[Taco Loco]

So when is this heap getting sold? I thought you had a buyer or 2 a few weeks back. Sounds like its a lot of work.

So he will probably take less now, transmission leaks and the front end is about to fall out from the bottom of it

 

[tex]

So he will probably take less now, transmission leaks and the front end is about to fall out from the bottom of it

I know the front diff is good since I helped tighten the bolts. The coils are another story. Sounds like its a parts rig. I will bring a trailer to pick it up. $1000 in hand.

 

[tx_shooter]

Look at these two comedians. @tex the last thing you need is another busted down vehicle in front of your house. Your neighbor might start to complain.

 

[tex]

Look at these two comedians. @tex the last thing you need is another busted down vehicle in front of your house. Your neighbor might start to complain.

I would welcome those assholes to come over and say something. They had another car show up the other week. Not sure what the fuck but I would probable punch anyone from that house that came over to my door steep.

 

[Mauzer]

I would welcome those assholes to come over and say something. They had another car show up the other week. Not sure what the fuck but I would probable punch anyone from that house that came over to my door steep.

Sounds like a fun neighborhood

 

[Oswego]

Sounds like a fun neighborhood

Sounds like my court. One bad neighbor kills the entire neighborhood with what seems to be 10 adults and 20 kids living in a 3 bedroom 1 bath house. I don't even mind the ex-heroin addict neighbor anymore as the new breed of bunny rabbits is MUCH worse.

 

[tx_shooter]

So this week has had a few changes to the list but this will be it until I get back from this weekends trip. The new shocks are riding great and the steering handles nicely with the new outer tie rods.

So the list stands today at:

2- Resolve power steering fluid leak
4- Build cargo storage/ drawer
5- Fridge slide out
7 - Dual battery setup w/ 25 series
8- Wind fairing for RTT
12- E-locker actuator rebuild
13- Camp Box build

Done:
1 - Front axle swap to 4.30 gears
9 - New rotors and pads
6 - Battery box
14 - tablet holder mount
3- Install auto transmission shift kit/ new solenoids
10 - Shocks
11 - Outer tie rods

 

[tx_shooter]

Getting the wind fairing done today. Currently waiting on the paint to dry.

 

[unevolved]

Nice, curious to see if you notice any changes.

 

[TacoXpo]

...and I for one, would love to see those ViceGrips stay permanently!

 

[Taco Loco]

...and I for one, would love to see those ViceGrips stay permanently!

This.